The Marine Knowledge Network
Field write-ups from real jobs - what broke, what fixed it, torque specs and part numbers included. Ask it a question; specs answer inline.
23 articles for “inspection”
MerCruiser Alpha One Bellows Inspection: The Boat-Sinker Check
## Why this is the most important sterndrive inspection The u-joint bellows is the ...
Sea-Doo Jet Pump Wear Ring Inspection and Replacement
... ring or chewed impeller edges at inspection ## Inspection 1. Ski off the water, on ...
Exhaust Manifold and Riser Inspection on Marine V8s
... at the manifold-to-riser joint ## Inspection procedure 1. Cold engine. Remove the riser ...
Sterndrive Spring Recommissioning Checklist
... If unknown, inspect for freeze cracks along the block sides and manifold ends **before ...
MerCruiser Raw Water Impeller: Alpha vs Bravo Differences
... Inspect the driveshaft, u-joints, gimbal bearing, and all bellows **while the drive is ...
Spring Recommissioning Checklist: Outboard Boats
... inspected spark plugs — check the service manual for the plug type and gap. - Inspect ...
Boat Trailer Bearing Service (and Bearing Buddy Myths)
... Clean bearings in solvent and inspect races and rollers under good light: pitting, blueing ...
Volvo Penta Sterndrive Annual Service Essentials
... full-travel inspection of driveshaft, exhaust, and shift mechanisms with a light and mirror ...
Outboard Compression Testing: How to Do It and Read the Results
... Do it before quoting carb work, tune-ups, or any pre-purchase inspection — no ...
Pontoon Boat Inspection: Logs, Leaks, and Pre-Season Checks
## Pontoons hide their problems below the deck A pontoon that "sits low on one ...
Mercury Outboard Water Pump / Impeller Replacement
... replace it on spec, don't inspect it. ## Symptoms of a failing impeller - Weak ...
Trailer Surge Brakes: Inspection and Service
... and owners who have no idea. ## Inspection 1. **Actuator:** check the sliding tongue for ...
Suzuki DF Lower Unit Oil Change and Water Intrusion Signs
... fishing line (pull the prop and inspect the seal area every time) - Drain/vent ...
MerCruiser Winterization (Raw-Water-Cooled)
... joints/gimbal via fittings where present, inspect bellows, and store the drive **down** so ...
Sea-Doo Winterization Step by Step
... Lube cables and pivots; inspect the carbon ring/boot and the pump while it ...
Sea Trial Checklist for Mechanics
... It's also a billable diagnostic product for pre-purchase inspections. Run the same ...
Yamaha WaveRunner No-Start Diagnosis
... rail against the manual's spec, inspect for stale/varnished fuel from storage. 4 ...
Honda BF-Series Carburetor Cleaning
... won't clear, replace it. 6. Inspect the needle valve tip for wear rings ...
Quoting a Repower: The Mobile Mechanic's Guide
... conditions stated ("if fuel hose fails inspection...") - Explicitly list exclusions: transom repair, tank replacement ...
Evinrude/Johnson Two-Stroke No-Spark Diagnosis
... visible tar means it's done. Inspect the flywheel magnets for cracks and debris ...
Bilge Pump Setup Done Right
## The system that saves boats while nobody watches A bilge pump setup is only ...
Reading Marine Spark Plugs: A Diagnosis in Your Hand
... where the manual says to. 4. Inspect plug wires/coil boots while you're ...
Prop Hub Replacement and the Spun-Hub Field Call
... Clean the shaft splines and **inspect for fishing line at the seal** — every single ...